charging diesel batteries
Marine Diesel Engine Maintenance
In a conventional marine diesel engine the power is produced by hot compressed air igniting fuel sprayed under very high pressure into the cylinder head. A marine diesel engine does not use a carburetor to mix fuel and air or spark plugs to ignite the mixture. Instead it employs the pistons to compress the air to 3000 kPa which causes it to become extremely hot and the fuel is ignited as soon as it is injected into the cylinder.
Some marine diesel engines are fitted with a heater plug in the inlet manifold or a glow plug in the pre-combustion chamber of each cylinder to provide additional heat to the combustion air during starting.
Diesel engines are heavier and slower revving than petrol engines but they are also more reliable because they do not rely on external carburetion or an electrical spark for ignition.
Newer engines use an electronic fuel injection system whereby fuel and air are mixed more thoroughly in the pre-combustion chamber before entering the cylinder. This system maximizes power and fuel economy and is also less polluting.
Every boater should have an understanding of how their engine works so let’s start by explaining the mechanical cycles.
Most reciprocating piston internal combustion engines work on one of two mechanical cycles-either the four-stroke cycle or the two-stroke cycle. These cycles designate, in correct sequence, the mechanical actions by which the fuel and air gain access to the engine cylinder, the gas pressure – due to combustion – is converted to power and, finally, the burnt gas is expelled from the engine cylinder.
The Basic Four-Stroke Diesel Engine
From its name, it is obvious there are four strokes in one complete engine cycle. A stroke is the movement of the piston through the full length of the cylinder and – since one such movement causes the crankshaft to rotate half a turn – it follows that there are two crankshaft revolutions in one complete engine cycle.
The four strokes in the order they occur are:
1. Inlet stroke. With the inlet valve open and the exhaust valve closed, the piston moves from top dead center (TDC) to bottom dead center (BDC), creating a low-pressure area in the cylinder. Clean, filtered air rushes through the open inlet valve to relieve this low-pressure area, and the cylinder fills with air.
2. Compression stroke. With both valves closed, the piston moves from BDC to TDC, compressing the air. During this stroke the air becomes heated to a temperature sufficiently high to ignite the fuel.
3. Power stroke. At approximately TDC, the fuel is injected, or sprayed, into the hot, compressed air, where it ignites, burns and expands. Both valves remain closed, and the pressure acts on the piston crown, forcing it down the cylinder from TDC to BDC.
4. Exhaust stroke. At approximately BDC the exhaust valve opens and the piston starts to move from BDC to TDC, driving the burnt gas out of the cylinder through the open exhaust valve.
The Two-Stroke Diesel Engine
The two-stroke engine uses two piston strokes to complete one power stroke and, therefore, fire twice as often as a four-stroke engine. A two-stroke engine is smaller and simpler with fewer moving parts. A two-stroke engine has the potential to produce twice as much power as a four-stroke engine of the same size, however, because of the extra fitting required in a two-stroke diesel engine, for example blowers and governors, they become more expensive to produce. There has been a shift towards four stroke diesel engines which have become more efficient and smaller.
Protect Your Marine Diesel Engine
Protect your engine by avoiding long periods (more than 10 minutes) of idling in a “no-load” situation. This is often done to charge batteries or cool refrigeration but if done repeatedly it will glaze the bores of the engine and cause premature engine failure. If the vessel is in a berth the engine can be put in gear to create load at idle.
All boat owners should have an understanding of basic marine diesel engine maintenance to keep themselves and their families safe on the water.
About the Author
Chris Miley is an online author and a keen boater. You can find out more about maintaining your marine diesel engine at his website
Marine Diesel Secrets
and the
Pontoon Boat Site
.
|
|
Sunsei 71015 SE-24000 400-Watt 16.5-Volt Solar Panel Generator $1,014.23 A perfect match for back-up power in cabins, cottages, RVs and boats, the Sunsei Solar 400-watt 16-1/2-volt charger provides reliable, renewable energy as an alternative to noisy and expensive diesel, propane and gas generators. Giving power all year round when exposed to daylight, this solar charger produces 400 watts of high-efficiency polycrystalline charges for multiple batteries at once. With… |
|
|
ETQ TG1200 1,200 Watt 2 HP 2-Cycle Gas Powered Portable Generator $139.99 This generator is ideal for camping and powering small-scale household appliances like TVs or computers. 2-stroke, 63cc engine has recoil start and transistorized ignition. Meets EPA standards. Surge Watts: 1,200, Rated Watts: 1,000, Start Type: Recoil, Engine Displacement (cc): 63, HP: 2.6, Engine: 2-Stroke, 63cc, Run Time: 4.5 Hours at 1/2 Load, Receptacles (qty.): 1, Noise Level (dB): 69, Fuel … |
|
|
Kipor IG6000 6000 Watt Inverter Generator With Electric Start $2,199.99 This is a new Kipor Sinemaster IG6000 (was called KGE6000Ti) Digital Inverter generator with electric start. It has dual voltage – 120V and 240V output on the 50AMP RV (on large motorhomes and 5th wheel) receptacle. This generator looks like the smaller KGE3500Ti but is bigger all around. You can start the engine like starting a car with the electric start. It is brand new in box and in stock read… |
|
|
BlackBerry Visor Mount Bluetooth Speakerphone $45.99 The BlackBerry Visor Mount Speakerphone VM-605 is a hands free Bluetooth speakerphone from RIM. Enjoy your calls and your favorite music from your BlackBerry smartphone with the convenience and sound quality of your car’s FM stereo system. It’s easy to use. Just clip it to your car’s visor, turn it on, and you’re ready to start making and taking hands free calls on the go. And because it supports … |
|
|
Clore Automotive JNC660 1700 Peak amp 12-Volt Jump Starter $118.00 The JNC660 delivers 1700 Peak Amps and 425 Cranking Amps of starting power and weighs just 18 lbs. It’s perfect for a variety of professional starting environments, including automotive service, fleet service, auto dealerships, auto auctions, marinas, implement dealerships and more. Give it a try and you’ll see why it’s the choice of pros the world around. No-hassle charging and reliable perf… |
|
|
Battery Tender 2-Bank Battery Management System Motorcycle Battery Charger $129.95 Provides 12V-1.25A per channelFeatures a four-step microprocessor-controlled fully automatic charge programProtects against sparks, short circuits and reverse polarity while also protecting marginal batteries with a 72-hour safety timer… |
|
|
Schumacher SE-1-12S Fully Automatic Onboard Battery Charger – 1.5 Amps $22.42 Keep your rig’s battery fully charged at all times. Schumacher’s 1.5-amp, 12-volt Maintainer makes it easy. Schumacher’s 1.5-amp, 12-volt charger is the ideal way to maintain a battery’s charge. It’s the perfect solution if you don’t use your vehicle everyday, go short distances, or do lots of stop-and-go driving. This maintainer can also be used to charge small batteries for ATVs, motorcycles, sn… |
|
|
Solar charging for starting: AGCO installs solar panels on cab roofs to trickle charge tractor batteries.(AG EQUIPMENT): An article from: Diesel Progress North American Edition $9.95 This digital document is an article from Diesel Progress North American Edition, published by Diesel & Gas Turbine Publications on May 1, 2009. The length of the article is 734 words. The page length shown above is based on a typical 300-word page. The article is delivered in HTML format and is available immediately after purchase. You can view it with any web browser.Citation DetailsTitle: Solar … |
|
|
BatteryMole Car Battery Warning System (12 Volt Automobile Battery Monitor with Battery Failure Prediction Logic). Made in USA $39.25 Don’t get stranded. Your car should be smart enough to tell you when it’s time to replace the battery. Last year over 60 million automobile batteries were replaced in North America. Your battery could be among this year’s 60 million but your car doesn’t know it. The BatteryMole’s patent pending technology analyzes your vehicle’s battery and starting system like no other product. Simply plug this u… |
|
|
BlackBerry Visor Mount Bluetooth Speakerphone $45.99 The BlackBerry Visor Mount Speakerphone VM-605 is a hands free Bluetooth speakerphone from RIM. Enjoy your calls and your favorite music from your BlackBerry smartphone with the convenience and sound quality of your car’s FM stereo system. It’s easy to use. Just clip it to your car’s visor, turn it on, and you’re ready to start making and taking hands free calls on the go. And because it supports … |
|
|
Schumacher SE-1-12S Fully Automatic Onboard Battery Charger – 1.5 Amps $22.42 The Schumacher SE-1-12S Fully Automatic 1.5-amp Onboard Battery Charger is an AC powered automatic trickle charger / maintainer for use with 12 volt lead-acid batteries. The unit features an automatic charge cycling process that allows charging to turn on and off automatically as is necessary, and its “onboard” design and included hardware makes for easy, convenient mounting adjacent to batterie… |
|
|
BatteryMole Car Battery Warning System (12 Volt Automobile Battery Monitor with Battery Failure Prediction Logic). Made in USA $39.25 Don’t get stranded. Your car should be smart enough to tell you when it’s time to replace the battery. Last year over 60 million automobile batteries were replaced in North America. Your battery could be among this year’s 60 million but your car doesn’t know it. The BatteryMole’s patent pending technology analyzes your vehicle’s battery and starting system like no other product. Simply plug this u… |
|
|
Solar charging for starting: AGCO installs solar panels on cab roofs to trickle charge tractor batteries.(AG EQUIPMENT): An article from: Diesel Progress North American Edition $9.95 This digital document is an article from Diesel Progress North American Edition, published by Diesel & Gas Turbine Publications on May 1, 2009. The length of the article is 734 words. The page length shown above is based on a typical 300-word page. The article is delivered in HTML format and is available immediately after purchase. You can view it with any web browser.Citation DetailsTitle: Solar … |
|
|
Sunsei 71015 SE-24000 400-Watt 16.5-Volt Solar Panel Generator $1,014.23 A perfect match for back-up power in cabins, cottages, RVs and boats, the Sunsei Solar 400-watt 16-1/2-volt charger provides reliable, renewable energy as an alternative to noisy and expensive diesel, propane and gas generators. Giving power all year round when exposed to daylight, this solar charger produces 400 watts of high-efficiency polycrystalline charges for multiple batteries at once. With… |
|
|
ETQ TG1200 1,200 Watt 2 HP 2-Cycle Gas Powered Portable Generator $139.99 Take power anywhere with the affordable ETQ TG1200 Gas-Powered Portable Generator. Combining robust performance and a lightweight design, this generator is ideal for camping trips, hunting, traveling, and light residential use. It provides enough power to simultaneously run several household appliances..caption {font-family: Verdana, Helvetica neue, Arial, serif;font-size: 10px;font-weight: bold;f… |
|
|
Kipor IG6000 6000 Watt Inverter Generator With Electric Start $2,199.99 This is a new Kipor Sinemaster IG6000 (was called KGE6000Ti) Digital Inverter generator with electric start. It has dual voltage – 120V and 240V output on the 50AMP RV (on large motorhomes and 5th wheel) receptacle. This generator looks like the smaller KGE3500Ti but is bigger all around. You can start the engine like starting a car with the electric start. It is brand new in box and in stock read… |
